Club Clouds Cars
google9c5a85a2ff1b9e78.html

Conversion a Autostick

Ver el tema anterior Ver el tema siguiente Ir abajo

Conversion a Autostick

Mensaje  Yaomg1782 el Sáb Sep 22, 2012 11:25 pm

Hola bueno este tema es interesante para los que quieren hacer la conversion de la caja de 4vel a una autostick, es del bueno amigo club
[Tienes que estar registrado y conectado para ver este vínculo] es bueno tener esta información, esta pag es para otros coches
[Tienes que estar registrado y conectado para ver este vínculo]
[Tienes que estar registrado y conectado para ver este vínculo]
saludos


AutoStick conversion for 2.0, 2.4, and 2.5l 41TE Automatic Transmissions
------------------------------------------------------------------------

[Tienes que estar registrado y conectado para ver esa imagen]

------------------
Required parts:
1. AutoStick TCM (transmission control module)
2. AutoStick Shifter (left and right motion w/ Autostick module)
3. AutoStick Instrument Cluster (P R N D 1234)
[Tienes que estar registrado y conectado para ver esa imagen]
4. Connector and wire to connect shifter and TCM and provide power/ground.
Optional parts:
1. AutoStick Shifter Bezel (to replace P R N D 3 L)
[Tienes que estar registrado y conectado para ver esa imagen]
2. AutoStick Shifter Boot (larger leather boot, not vinyl)
[Tienes que estar registrado y conectado para ver esa imagen]

*Note: It is been said that you can use a computer connector to use on the shifter. Its the 4-pin connector used on CD-ROM drives for audio. It is an alternative if you cannot get the real connector used on the shifter. I used the real connector.

Estimated cost: $200 - $500
(depending on your sources)
------------------

--------------
Installation:
--------------
There is no real order to this as it is purely electronics. Just don't turn on
the car without completing all of the steps. The car will work if you have some
of the parts installed, but it is just not worth the time unless you have *all*
the parts.
1. Remove automatic TCM.
2. Install AutoStick TCM.
3. Leave the TCM harness off for now.
4. Remove Instrument cluster (if you read the "Reverse Gauges How-To" there is
more detailed info)
5. Install AutoStick Cluster
6. Leave the dash apart for now.
7. Remove the center console (remove the Shifter bezel, 2 screws there, 2 more in the inside of the console)
8. Remove the shifter.
9. Take this time to snake your wire through the middle to the TCM by going up the dash and across to the left through the firewall (i'll get pics)
10. Install the AutoStick shifter.
11. Use the connector to join the wire to the AutoStick shifter module. (i'll have pics) Follow the wire diagrams below to connect the wires.
12. Plug in the wire into TCM harness. This involves drilling into the correct pin holes. This is
neccessary because Chrylser put in some stupid little dot things that block the wire from reaching
the bottom. Take note of the wire diagrams below.
13. Make sure the TCM is looking sharp, close the hood, reattach the dash parts, and attach your new autostick shifter bezel and boot if you got it.
14. Start the engine. Do not move your car yet...
15. Shift through each gear, taking about 2 seconds in each gear. Down and up, at least twice. When you reach A (autostick) it should light up [1] on the cluster! If so, it works for you! I believe this will allow the new TCM to relearn your shift points.
Besides it won't hurt anything anyway. Getting in and going quickly isn't good on the transmission.
16. Test drive and try out manual shifting. Very Happy

------------------
Wire Diagrams:
------------------
TCM Diagram 1

[Tienes que estar registrado y conectado para ver esa imagen]

TCM Diagram 2

[Tienes que estar registrado y conectado para ver esa imagen]

[Tienes que estar registrado y conectado para ver esa imagen]

[Tienes que estar registrado y conectado para ver esa imagen]

AutoStick Shifter Module connector

[Tienes que estar registrado y conectado para ver esa imagen]

Yellow = Downshift sense
Green = Upshift sense
Black = ground
Red = 12v Power (I used the cigarette lighter)

I believe I covered everything. There isn't that much to this. The hardest part is finding the parts and getting them at a decent price. I'll update this page with more pictures tomorrow when it is daylight.
avatar
Yaomg1782
Administrador Fundador
Administrador Fundador

Fecha de inscripción : 11/09/2012
Edad : 34

http://clubcloudscars.foroactivo.mx/

Volver arriba Ir abajo

Re: Conversion a Autostick

Mensaje  Yaomg1782 el Jue Ene 22, 2015 2:33 pm

avatar
Yaomg1782
Administrador Fundador
Administrador Fundador

Fecha de inscripción : 11/09/2012
Edad : 34

http://clubcloudscars.foroactivo.mx/

Volver arriba Ir abajo

Re: Conversion a Autostick

Mensaje  Yaomg1782 el Jue Ene 22, 2015 4:02 pm

avatar
Yaomg1782
Administrador Fundador
Administrador Fundador

Fecha de inscripción : 11/09/2012
Edad : 34

http://clubcloudscars.foroactivo.mx/

Volver arriba Ir abajo

Re: Conversion a Autostick

Mensaje  Contenido patrocinado


Contenido patrocinado


Volver arriba Ir abajo

Ver el tema anterior Ver el tema siguiente Volver arriba

- Temas similares

 
Permisos de este foro:
No puedes responder a temas en este foro.